Results 1 to 7 of 7
01-04-2008, 01:13 AM #1
Idler Pulley and tensioner pulley replacement
i had a bad squeek from under the hood when it is cold or at different times. i was able to track down the bad part the pulleys. here are the stock plastic pulleys.
there is one below and one to the right of the ac compressor.
here is a better view of them
here are the replacement pulleys. i go the steel upgrades for a couple dollars more. these were NAPA part number 38001 and 38006.
i removed the serp belt and set aside. i used a 15mm wrench to remove the idler pulley. you can see the old and new pulley.
1993 4X4 Suburban
many other toys as well
01-04-2008, 01:17 AM #2
here is the back side of the pulley. the old and the new.
you can see how the system works. the bolt goes thru the pulley then the spacer and then the o-ring.
i cleaned the bolt threads and spacer and then added a small amount of anti seize so i could replace the parts if needed
the belt tensioner pulley is a different setup. the threads are left handed so you got to go the opposite way to remove the bolt. here is the old and new pulley
01-04-2008, 01:25 AM #3
here is the back side of the pulleys
here is how the bolt goes on the tensioner
i cleaned the parts off on the wirewheel. here they get a small dab of anti seize
here is the installed picture
if this was all you needed to do then you install the serp belt after inspecting it and replacing if needed. i needed to swap the P/S pump so i do not have a completed shot here.
01-04-2008, 07:16 AM #4
Awsome write up on this ! ...
we should have a "to do" forums section so when someone has this problem in the future they dont need to be searching for the thing04 Tahoe LT 5.3L stock MSD 8.5mm Wires
Gigbson Duels Straight Exhaust, Parrot 3100 Bluetooth
K&N 77 Series CAI, Sirius Radio
De-badged, Valet Dei remote start
5000k HID -Higherlevelauto.com
Federal 100watt air horn
01-04-2008, 12:07 PM #5
in the other groups i belong to they o have a Tech Write Ups - Installs and it is only for TECH and installs no questions as that is the other threads
this is an example link
01-04-2008, 01:18 PM #6
- Join Date
- Dec 2004
- Arlington, Texas, United States
- Blog Entries
10 Chevy Traverse LT AWD
02 Chevy Trailblazer LS (110K+ miles - loaded except for 4WD - WRECKED!)
99 Chevy Cavalier LS (105K+ miles - commuter car)
78 Chevy Suburban Silverado (454, 3/4 ton)
62 GMC 3/4 ton Pickup (350 police interceptor)
Remember: Search Before Posting | Fill out Your Profile & Signature
* I've been saying for years that I was going to change my username, and I finally did.
01-04-2008, 01:20 PM #7
- Join Date
- Feb 2007
- Blog Entries
1991 Chevy Suburban 1/2 ton 2WD w/ chevy SBC 350-3/4 ton drivetrain upgrade w/4.10 gears 200K miles
2005 Saturn ION-2 Stock 277K miles
1982 Bronco, 1993 Bronco (sold), 1971 M35A2 Deuce and a Half
There are 10 kinds of people, those who understand binary, and those who dont...
Remember kids, the only difference between screwing around and science is writing it down- Adam Savage
By green4191 in forum GM PowertrainReplies: 12Last: 11-02-2011, 06:11 PM
By GSXR-Freak in forum Chevy Silverado Forum (GMC Sierra)Replies: 3Last: 04-27-2011, 07:57 PM
By wolverine_22 in forum General Chevy & GM Tech QuestionsReplies: 1Last: 04-20-2010, 08:46 AM
By Nevada Born in forum Chevy Trailblazer Forum (GMC Envoy)Replies: 1Last: 06-20-2008, 02:20 AM
By BOWSINGLINE in forum Chevy Suburban Forum (GMC Yukon XL)Replies: 7Last: 05-30-2008, 11:30 PM
Tags for this Thread