Results 1 to 10 of 12
Thread: Which gear oil? 2005 yukon xl
05-15-2013, 09:39 AM #1
Which gear oil? 2005 yukon xl
I an going to change the gear oil in my rear diff today or tomorrow. My manual recommends 75w-90 synthetic gear oil. The only 75w-90 that I can find is for limited slip diffs, I have a G80 Gov-Loc. I am looking at using Mobile 1 75w-90, amsoil, or Mobile Delvac (if I can find quarts of it. alternatively it is $47 a gallon) I do tow a boat very often in the summer, but not very far. I have read of guys going to 75w-140 because they tow. Does anyone feel as if this is necessary? Any recommendations on which gear oil to use? I have read some bad things about Lucas and Royal Purple. I would consider amsoil. But, can not find a place near me that carries it or that I can get a significant discount at. I can pickup 3 quarts of Mobile 1 for $22 after discounts. Any suggestions? I may attempt to get a hold of @1st Synthetics and see what his prices are for the 75w-90. Looking online I can only buy amsoil in cases of 12.
- - - Updated - - -
I am going with amsoil, I will return the mobile 1 I just purchased. I spoke with Scott from 1st Synthetics and his prices for guys on the forum are pretty darn good. So, i will be driving down to get it tomorrow.
Last edited by Pikey; 05-15-2013 at 09:01 AM.
1995 Silverado 4x4
6" BDS Suspension Lift-3" Body Lift-Add A Leaf in rear -Trailmaster SSV Shocks-Duel Steering Stabilizer Kit -AirAid Cold air intake-
4.56 Gears with Detroit Auburn Locker-Pro-Comp Traction Bars with duel shocks-Aluminum Skid Plate Kit-38.5" x 16.5" Mickey Thompson Baja Claws-Constant Dropping fuel gauge
2005 Yukon XL Jet Power Programmer, Bilstein Shocks, Bilstein rear springs, Helwig Anti-sway bars, EGR Window Visors, EGR Hood Shield, Denali Headlights, Headlight harness upgrade, GE NightHawk Bulbs, White Night Rear lighting system, Russell Braided SS brake lines, PowerStop Brake pads, PowerStop cross drilled and Slotted Rotors, http://www.gmtruckclub.com/forum/sho...5-GMC-Yukon-XL
2002 Silverado ext cab 2wd (Sold)
2003 Yukon XL (Totaled)
05-15-2013, 11:06 AM #2David
2004 Silverado 2500 Crew Cab 4x4, AMSOIL EA air filter, Granatelli MAF sensor, Throttle body spacer, Magnaflow exhaust (true dual to 2 in 1 out muffler), 6" ProComp lift (add a leaf and 5" superlift rear block), Bilstein shocks, 35's (Cooper Disoverer ST) and 4.10 gears, Rhino Liner, EGRUSA fender Flares and widow visors, extended stainless steel brake lines, firestone airbags w/onboard air compressor, Pioneer Avic X940BT navigation, Accel backup camera.
1960 Land Rover Series II 88
2001 Pontiac Sunfire
2013 Toyota Avalon Limited (Wife's Car)
NRA Life Member
05-15-2013, 11:09 AM #3
Scott at 1st synthetics gives all forum members here wholesale pricing.
05-16-2013, 09:40 AM #4
I have owned several 2500s, mostly Dodge and now this Silverado.
I always dump the factory fill early, and in the last two (the last Dodge and this Silverado) I used Mobil 1 75w90. I noted in the Dodge (and dumped the Mobil 1 early as a result) that the differential started whining with less than 10k miles on the oil. I swapped over to Royal Purple 85w140, and no more noise for the next 200k miles. I read all the reviews and it seemed Mobil 1 or Amsoil were the two choices for the Silverado and G80. Same thing, 10k miles (15k total) and the differential developed a noticeable whine.
I happened onto a 5-gallon pail of Amsoil SVO (severe gear 75w140) for $50 a couple months ago...decided this weekend to swap out gear oil yet again. Differential is absolutely quiet now...not a noise.
I am a firm believer that 75w90 is a fuel mileage/CAFE thing, and not adequate for a full size truck. I have had good luck with 75w140 and 85w140, and I will continue to run both.
05-16-2013, 12:01 PM #5
well, the fluid change is going to have to wait. I crawled under there and realized that there is no drain plug and the hole is directly next to the pinion so I can not get my mighty vac tube in there. Thanks GM! My 2002 had a drain plug. I don't have time today to pull the cover.
Last edited by Pikey; 05-16-2013 at 12:15 PM.
05-16-2013, 02:40 PM #6
05-17-2013, 09:18 AM #7
Well, I changed the fluid last night after class. There happens to be a parts store a few blocks away from my school. So, I went during break and grabbed the gasket. I am glad I changed it! It was pretty nasty and had the consistency of water. I assume that it had been done at least one time before because the way rtv sealer was spread all over the place. I did not think that I had rear end noise before. But, after changing the fluid it seems much quieter.
All together it took me about an hour and a half. That is because my ocd kicked in. The cover was covered in flaking rust. So, I wire wheeled all the rust off, primed it with a self etching primer, and sprayed it with black paint. Unfortunately, the only black paint I had was high gloss. No one will see it under there anyway. I tend to go a little over board on things like this also. I drained the diff, sprayed everything down with brake clean, covered the gears in a plastic bag, and then cleaned the mounting surface, with a wire wheel on a dremel, until all rust and rtv was removed and the surface was nice and shiny, then removed the bag and resprayed everything, I cleaned the cover on my bench grinder. Then, I put a layer of rtv on both mating surfaces and applied the gasket. I know that many guys say that there is no need to do both gasket and rtv. I would rather use a $5 tube of rtv and a $5 gasket and not have to redo it because it is leaking.
Last edited by Pikey; 05-17-2013 at 09:28 AM.
05-20-2013, 10:29 AM #8
i used 85-145 royal purple in mine, with the added capasity aluminum cover, so it tool almost 3qrt
i dont think i even need to change it again lol
i went super thick so it would coushion the gears and posi an much as posible for banging gears, towing, and offroading. cause this truck sees eveything given timeGas was $1.83 when Obama took office.....
05-20-2013, 11:49 AM #9
I know some folks don't like Royal Purple (I for one only like their gear oil), but I had good luck with it in the last truck. The last truck took nearly eight quarts with an aluminum ORU cover...that was an 11.5" AAM though.
06-03-2013, 07:40 AM #10
And those semi diffs get Mobil 1 75w90 synthetic just like has been mentioned here. They came factory filled with it, and still use it.
Last edited by Cowpie; 06-03-2013 at 08:06 AM.2013 Silverado 1500 LT Z-71 Crew. 5.3L Auto. Range AFM Delete, PCV Catch Can, RC Leveling kit, Dynomax Ultra Flo cat back, Airaid M.I.T.
2013 Freightliner Columbia. pre-EGR Detroit 12.7L 500 hp 1850 lb torque, 18 speed.
By parts bot in forum Chevy Parts eBayReplies: 0Last Post: 05-10-2013, 04:10 PM
By original68 in forum Chevy Tahoe Forum (GMC Yukon, Cadillac Escalade)Replies: 17Last Post: 12-17-2011, 10:25 AM
By Dons31a in forum GM PowertrainReplies: 3Last Post: 07-07-2011, 09:49 AM
By 68camaro in forum GM PowertrainReplies: 6Last Post: 11-29-2010, 04:58 PM
By ajb09101963 in forum Chevy Tahoe Forum (GMC Yukon, Cadillac Escalade)Replies: 2Last Post: 04-26-2008, 08:33 PM
Tags for this Thread