Results 1 to 8 of 8
05-06-2013, 10:05 PM #1
- Join Date
- May 2013
my 78 k10 front Drive spins full time. Is that normal?
Last edited by jessafiddle; 05-06-2013 at 11:35 PM.
05-06-2013, 11:36 PM #2
- Join Date
- Jul 2010
- Denver, CO
- Blog Entries
Hi jessafiddle and welcome to the Club!! Congrats on your new ride too!
I moved your thread to the Powertrain section of the forum as this will help in getting more opinions and responses.
Mike (Denver, CO) - 2008 Sierra 1500 Z71 SLE 5.3L 4WD
SUSPENSION: Rancho 4" Suspension Lift; Rancho RS9000XL Shocks; Rancho Skid Plates; Rancho MyRide Wireless Shock Controller;
TIRES: BFG All Terrain KO 315/70/17
DRIVE TRAIN: 4.56 Gears; Detroit TrueTrac Differential; True Cool 40k Transmission Cooler
PERFORMANCE: DiableSport Predator Tuner; Custom Tuned by Diablew; Magnaflow Exhaust; AFE Cold Air Intake
ELECTRONICS: Kenwood DNX6180 Touchscreen; Subthump box w/10" Kicker; Driver Information Center (DIC); Rear View Camera
ACCESSORIES: Westin Brush/Grill Gaurd; Westin Nerf Bars; Truxedo Tonneau; 20% Tint; Tow Mirrors w/Heat & Signals
05-07-2013, 12:22 AM #3
Sorry I can't help with which tc it is but I know my front shaft spins full time. One way to see if there is a problem is to get all four tires off the ground and put it in drive. See if the front tires spin in 2wd (they shouldnt) and then again in 4wd.David
2004 Silverado 2500 Crew Cab 4x4, AMSOIL EA air filter, Granatelli MAF sensor, Throttle body spacer, Magnaflow exhaust (true dual to 2 in 1 out muffler), 6" ProComp lift (add a leaf and 5" superlift rear block), Bilstein shocks, 35's (Cooper Disoverer ST) and 4.10 gears, Rhino Liner, EGRUSA fender Flares and widow visors, extended stainless steel brake lines, firestone airbags w/onboard air compressor, Pioneer Avic X940BT navigation, Accel backup camera.
1960 Land Rover Series II 88
2002 Nissan Altima (My Commuter)
2013 Toyota Avalon Limited (Wife's Car)
NRA Life Member
05-07-2013, 10:44 AM #4
I could be wrong, but I thought there were basically 2 different transfer cases used in that time frame - NP 203 Full time 4wd or the NP205 part time 4wd. What are your shifter positions? traditional 2H-4H-4L-N or do you have Hloc-H-N-L-Lloc?
From this site http://www.chuckschevytruckpages.com/drivetrains.html and looking at the position of the speedo cable and the fill hole, I would say you have the 203 full time case. It is normal for this case to spin the front driveshaft, as it sends power to the front and rear all the time.'98 K1500 Suburban LS 5.7 L 4L60E NV246 ARB
'92 Ford Explorer XLT 4x4 4.0 L A4LD BW13-54 Trac-loc rear
"My toys were the greasy cogs and springs and pistons that lay around all over the place, and these, I can promise you, were far more fun to play with than most of the plastic rubbish children are given nowadays." Danny in Roald Dahl's Danny The Champion of the World
05-07-2013, 06:36 PM #5
05-07-2013, 06:38 PM #6
05-07-2013, 10:50 PM #7
So it seems pretty sure that you have the full time 4wd NP 203 transfer case.
Way back when I can recall helping my dad take our '75 203 apart to install the part time conversion kit. The 203 is big and heavy, but pretty simple in operation, too. In H and L, it is like having an open diff in the transfer case. power goes to both front and rear, but the differential in the t case allows the front and rear to spin at different speeds while turning. With open diffs, it also means that, when you have one wheel in the air, all the power goes to that wheel and you are stuck. In Hloc and Lloc, the center diff in the transfer case is locked, forcing both front and rear to spin at the same speeds.
In many ways, I always like the basic idea of the full time 4wd like this. In particular, I thought it was nice to have the Low unlocked mode, which can be real useful for backing up trailers or other times when you want to gear reduction, but you don't necessarily need to lock the center diff.
05-07-2013, 10:54 PM #8
It looks like someone has put on lockout hubs...or I am I just imagining that. There was a kit in the old days that used lockouts and pieces for the transfer case that turned the 203 in to a part time transfer case. The 203 was notorious for stretching the chain and then jumping in the case. Made a hell of a noise.2013 Escape Titanium 4WD
By esbmann in forum Member IntroductionsReplies: 5Last Post: 10-19-2011, 06:41 PM
By Speedbump in forum Chevy Truck Tech ForumReplies: 7Last Post: 09-20-2011, 10:13 AM
By marty6464 in forum General Chevy & GM Tech QuestionsReplies: 20Last Post: 02-13-2011, 08:32 AM
By Phoebe in forum General Chevy & GM Tech QuestionsReplies: 5Last Post: 12-06-2010, 06:46 PM
By vncj96 in forum General Chevy & GM Tech QuestionsReplies: 6Last Post: 10-08-2008, 01:20 PM