Results 1 to 3 of 3
Thread: Wiring harness to fuel pump
06-16-2010, 07:07 AM #1
- Join Date
- Jan 2009
Wiring harness to fuel pump
I need help from the community again.
I have a 1997 Express 2500 van and I'm troubleshooting some fuel pump issues.
I have replaced the pump that was intermittent in it's operation and still have no fuel pumping or hear the sound of the pump working. I have replaced the fuel pressure relay.
Is there another fuse in the box under the hood?
My diagram on the box lid is messed up and I can't read it.
I noticed a section of the harness had been pinched against the frame and so I want to check those wires for the proper voltage.
I have 4 wires in the harness.
Black (largest wire gauge of the four)
Tan or Yellow (I can't tell exactly)
Also, when I put in the previous pump about 2 years ago, immediately the fuel gauge would go back and forth when using the turn signal.
With this new pump the gauge fluctuates the same way.
Any help is appreciated!
06-18-2010, 01:01 PM #2
- Join Date
- May 2010
- Central IL
- Blog Entries
It sounds almost like a ground problem to me, with the turn signal/gauge issue.
Get a manual for it, and check to see which wires are which. Check the ground (probably the straight black) vs the chassis with a multimeter and make sure it's not open (open = not connected to ground). Then check the feed wire with the key on (or while having someone turn the key on for you, as they'll cycle up and shutoff when pressure is achieved). If you have no power on the feed wire, then check at the relay and make sure it's outputting power when key is turned on.
With electrical you just have to kinda work through it till you find the culprit. Multimeter and test light are your best friends1986 Chevy G20 Tow Rig - 5.7 TBI conversion
1978 Mustang II King Cobra Road Racer - Holley 650, MSD 6AL, 5 speed, 10 point Roll Cage, 9" posi, fuel cell, custom interior.
06-20-2010, 06:53 AM #3
Did you replace the pump only, or the entire sending unit?When you hear hoofbeats, look for horses not zebras.
By alchemist1 in forum GM Electrical TechReplies: 3Last Post: 11-16-2011, 07:46 AM
By cj5daddy in forum General Chevy & GM Tech QuestionsReplies: 1Last Post: 03-20-2010, 05:54 AM
By JOHNNYBLACKEYE in forum General ClassifiedsReplies: 0Last Post: 02-08-2010, 11:16 AM
By MPB7000 in forum General Chevy & GM Tech QuestionsReplies: 0Last Post: 11-12-2009, 08:48 PM
By ONETONMIKEK30 in forum General Chevy & GM Tech QuestionsReplies: 2Last Post: 12-08-2008, 10:01 AM
Tags for this Thread