Results 1 to 10 of 28
06-14-2011, 05:16 PM #1
Compressed Natural Gas...I'll try to answer your questions
Several members have asked that I "spill my beans" on compressed natural gas (CNG) vehicles or natural gas vehicles (NGV).
First off, I will tell you a little about myself. I am a design engineer working a company that does research and development on composite overwrapped pressure vessels (COPVs) - like paintball cylinders, self-contained breathing cylinders (SCBA) for firefighters, compressed natural gas cylinders, high pressure hydrogen cylinders, the list goes on. I have designed and tested my fair share of high pressure (3,000 psi +) tanks.
Now onto the world of CNG. NGVs have been around for a long time, the first NGV was invented back in the 1920's. NGVs have slowly gained some ground and now there are approx. 150,000 NGVs in the US today. There are two main reasons why NGVs have not taken over the automotive industry like in other countries:
1. Chicken and egg issue - What do you have first, cars that run on natural gas or fueling stations to fill the cars that run on natural gas? The automakers don't want to mass produce NGVs because there is not a lot of fueling stations. The fueling station manufacturers don't want to make fueling stations if there are no NGVs to fill up.
2. Three letters - E.P.A. - This is a heated topic. There are good arguments on both sides. The EPA is concerned because it is possible to convert a vehicle to run on both gasoline and CNG and have the CNG burn DIRTIER than gasoline. Yes, CNG can burn dirtier than gasoline. If the guy doing the conversion does not know his stuff, then you can burn up a cat in no time and also either the hydrocarbons, CO, or NOx will go through the roof. The EPA has a mandate out that it is illegal to tamper with the OBD emissions system of the original manufacturer unless you have an exemption from the EPA to do so. This is only valid for a vehicle which is within its "useful life". This has created a "bottle neck" for aftermarket conversion shops to convert vehicles to CNG. The EPA has recently relaxed their rules a little bit but still require that the converted vehicle be tested to prove that it runs cleaner on CNG than on gasoline.
With NGVs, safety is the main concern. All CNG converted vehicles should comply with NFPA 52 installation code. High pressure gas is a serious thing and should not be underestimated. Now, don't be scared, CNG is actually safer than gasoline. When you get into an accident, and your gasoline tank is punctured, the gasoline just pools on the ground and if there is a fire - bye bye. With CNG, when there is an accident most likely the tank will not rupture (it is designed to withstand serious loads). If there is a fire, the natural gas will not ignite. Natural gas can only ignite if the air-fuel ratio is between 5% and 15%. In other words, not enough air - natural gas will not ignite, too much air - natural gas will not ignite. If your tank vents the gas due to a fire, then the gas will float away. Natural gas is lighter than air.
The key here is finding someone who "knows their stuff" on performing a good solid conversion. I have seen my fair share of shady conversions that even scare the crap out of me. Don't sacrifice safety for money.
Now on to your questions....
2003 Bi-Fuel 2500HD CNG/Gasoline (equivalent 40 MPG)
2003 Bi-Fuel Cavalier CNG/Gasoline (equivalent 90 MPG)
06-14-2011, 05:55 PM #2
- Join Date
- May 2011
- Upstate South Carolina
- Blog Entries
So what kind of range can you expect out of CNG compared to gasoline on a per unit basis? Where do you buy it?
I have heard of companies in California that sell home CNG units but they are not available outside of California. The home unit basically fills you tank from the natural gas line running to you home. That would be a viable option for me since I do not know of any place near my home where it is available.
What kind of cost to convert a typical v8 to run on CNG?
06-14-2011, 06:03 PM #3
I know that in Norfolk VA one of the utility companies use CNG to power their fleet of cars. I don't think they use it in their utility trucks but they do use it in the cars the meter readers drive and cars like that. I was told (never looked into the truth of it) that if a company had CNG that they also had to make it available to the public. Most likely at a higher price. When I lived in the Tidewater area I worked at a compressor company that manufactured service pumps to fill CNG cylinders. I think they got in on it early hoping for the big CNG boom.
06-14-2011, 07:40 PM #4
There are three types of NGVs:
1. Dedicated - these vehicles run exclusively on CNG. The engines in these vehicles are specifically tailored to CNG. The miles per gge are comparable to their gasoline sisters. Example: Honda Civic GX and Honda Civic LX get approx. the same miles per gge or miles per gallon.
2. Bi-fuel - these vehicles can run on either gasoline or CNG. The engines in these vehicles are tailored to run on gasoline. So when running on CNG, they are not optimized for fuel economy nor power. Typically at highway speeds there will be little if any notice in miles/gee versus miles/gallon. City driving is different. On CNG, the miles/gge is lower than miles/gallon on gasoline.
3. Dual-fuel - These vehicles are diesel/CNG vehicles that run about 70% CNG and 30% diesel at the same time. I don't have much experience with these vehicles, but from what I've heard they have increased horsepower.
BRC Fuelmaker makes a vehicle refueling appliance or VRA. Yes you can use the natural gas in your home to fill your CNG vehicle. They are available almost anywhere natural gas is used in the home (even outside of California). The most common unit is the Phill, but BRC Fuelmaker makes other models as well.
The cost on converting a typical V8 is about $8,000 - $12,000. The most expensive component is the CNG tank. Tanks vary in price by size. A brand new 20 GGE tank is about $3,500. Depending on the type of system that is installed the price may go up or down. The most inexpensive system is what is known as a fumigation or aspiration system. This system dumps the natural gas into the air intake. The most common system now days is the injection system. In a bi-fuel vehicle, a CNG injection system is totally separate from the gasoline injection system. On my truck I have two injectors per cylinder. So I 8 gasoline injectors and 8 CNG injectors.
---------- Post added at 06:40 PM ---------- Previous post was at 06:28 PM ----------
1. Tax incentives - Each state is different on how much you will recieve as a tax credit for converting or purchasing a NGV. You need to check with your state and see if there are incentives for NGVs. For example, in Utah there is up to a $2500 tax credit for converting or purchasing a NGV.
2. How much you drive versus how much CNG is at the pump - Again this varies from station to station and state to state. See http://www.cngprices.com/ and see how much CNG at the pump is near you. On that note, most of the stations in California, New York, Arizona, Nevada, and Colorado are owned by Clean Energy. They buy the natural gas from the utility company and compress it and sell it at the fueling station. Clean Energy's CNG is typically 50 to 80 cents cheaper than gasoline in that area. Utah and Oklahoma are different. In those states, the fueling stations are ran by the local gas utilities and their prices are set by the state's public service committee (PSC). It literally takes an act of Congress to raise or lower the price of CNG in those states.
Here is my example on payback:
In 2007 I bought a 2001 Chevy Cavalier (bi-fuel) for $5300. I got a $2500 Utah tax credit and I was saving 6 to 7 cents a mile when running CNG. So, in just over 43,000 miles the car had paid for itself ((5300-2500)/.065=43077) and then any miles driven after that is pure savings.
If you would like to do some digging about CNG yourself see http://cngchat.com there is a wealth of information there.
Last edited by Highmarker; 06-14-2011 at 07:53 PM.
06-15-2011, 10:39 AM #5
That was good reading Jared. Thanks for the info.:cool:
2005 Chevy Silverado Z71 Crew Cab
6" Skyjacker lift w/Edlebrock dual front remote resoviour shocks, single rear remote. Rancho skid-plate.
17" x 9" M/T Classic Lock Wheels, 35" BFG A/T or M/T tires
4.10 PercisionGears w/factory locker, T/A Performance rear-end cover
Banks CAI intake, ported throttlebody, JBA coated headers, over-sized Magnaflow cats, Magnaflow cat back exhaust, Diablo tuned
B&M aluminum deep transmission pan
Warn brush guard w/Warn 9.5 XP winch, PIAA bulbs, Line-X bedliner, AWS Black tool chest, Extang tonneau cover
Weather Tech floor mats
Cover-Craft seat covers
Dash mat cover
Formula One window tint
One black Lab in rear seat.
06-15-2011, 12:15 PM #6
06-15-2011, 01:13 PM #7
06-14-2011, 06:03 PM #8
This is some great information Jared, I am also an engineer so I am familiar with E.P.A strict guidelines. LOL. But from your experience what is the usually the pay back period for a CNG vehicle?2002 Chevy Silverado & 1995 Ford Bronco
02 Silverado: 50K miles, 20" Motto Rims, Flowmaster 50 Series
95 Bronco: 160K miles, 4" Superlift, 33/12.5/15 Mickey Thompson
01 Civic: 75K miles, DD
04-01-2014, 09:36 PM #9
- Join Date
- Dec 2004
- Arlington, Texas, United States
- Blog Entries
10 Chevy Traverse LT AWD
02 Chevy Trailblazer LS (110K+ miles - loaded except for 4WD - WRECKED!)
99 Chevy Cavalier LS (105K+ miles - commuter car)
78 Chevy Suburban Silverado (454, 3/4 ton)
62 GMC 3/4 ton Pickup (350 police interceptor)
Remember: Search Before Posting | Fill out Your Profile & Signature
* I've been saying for years that I was going to change my username, and I finally did.
04-01-2014, 10:04 PM #10
Thats because there is an abundance of Natural gas.. They were drilling and/or Hydrofracking here in the northeast so much that all of sudden it came to a halt mainly because they were finding more than they could sell. Also there are a lot of people against the hydrofracking and encouraging towns to put moritoriums on it until more information on its safety/health hazards are known. I was watching a government channel the other day and they anticipate that natural gas usage will increase 50% in the US by the year 2030. only 16 years away.. Looks like I wont have a problem finding work for the rest of my working days.. Ive been working in the natural gas industry for 15 years and a few years before that actually worked on a natural gas drilling rig for a couple years. Theres a lot of deteriorating pipelines out there that are climbing 100+ years old and if they are not replaced bad things happen.. We usually see on the news a good handfull of explosions every year due to the infrastructure falling apart. I have even replaced some of the plastic gas lines that were buried in the early 80's that are failing due to the oxidation of the plastic and are getting brittle. Im actually looking at getting some training to become a pipeline inspector when my body doesnt allow me to do the work im doing now. I think eventually there will be a call for it as soon as the government clamps down on some of the gas companies that have deteriorating systems.
2011 Silverado CrewCab 5.3L*Ram Air Look Cowl Induction Reflexxion Hood*6" Pro Comp Lift*Flowmaster Dual exhaust*Perfect Launch Rear Diff. Cover*Led Smoke Taillights*L.E.D.Smoke 3rd Brakelight*60" L.E.D. Tailgate Bar*Rearview Mirror Reverse Camera and Sensors*Smoke Headlight Covers*Front Bumper Grill Insert*Deezee Black Alum. Diamond Rail covers*20" Ultra Motorsports Rims wrapped with 35.5"B.F. Goodrich Tires*Inchannel Raingaurds*CAI*Bullydog GT Tuner*Alpine Amp*Boss 6x9's*Boston Acoustic Subs*Terrantula Tweeters*Custom Sub box*Red Led Interior Accents*5% Ultimacool duo tint rear window and doors, 20% front doors*Custom Vinyl Graphics*Demolded*Debadged*Painted drums and calipers*
Future Mods Include: Custom Interior Hydrographics, Electronic Rollup Toneau Cover, 4.56 Gears, Painted rear bumper
By Toddler in forum Performance & FuelReplies: 10Last: 12-14-2011, 10:03 AM
By topher91 in forum General Chevy & GM Tech QuestionsReplies: 10Last: 02-14-2009, 08:57 PM
By S/C Tahoe in forum Announcements & FeedbackReplies: 6Last: 12-21-2008, 12:43 AM
By Rancho5 in forum General Chevy & GM Tech QuestionsReplies: 8Last: 09-03-2008, 12:22 AM
By CJlambertz71 in forum The Coffee Shop ~ Chit ChatReplies: 2Last: 11-27-2007, 04:03 PM