GM Truck Club
THE PREMIER CHEVY TRUCK & SUV FORUM
Founded in 2004 ~ We're the #1 Chevy Truck & SUV Forum.
Silverado & Sierra | Tahoe & Yukon | Suburban & Yukon XL | SUV & CROSSOVER
Results 1 to 4 of 4
  1. #1

    Default Trouble With Blower Motor 95 chevy 1500

    What a headache, I replaced the blower motor, relay, resistor and the control assembly and have power at the blower motor (purple wire) using the ground wire and a test light the lower 3 settings have power and the high setting does not have power. The blower will not work on any setting. Tired of spending money with no result. Anyone have a suggestion?

  2. #2

    Default

    The problem has now spread to the wipers not working and the truck dies for no apparent reason, have to wait a few minuets to crank it back up. I think there's a short in the wiring somewhere. (pulls hair out) ..

  3. #3
    Legend
    stephan's Avatar
    Join Date
    Sep 2010
    Location
    Far West, Oregon USA,
    Posts
    8,606
    Blog Entries
    1

    Default

    Since this seems to have spread to the wipers & the engine, I would check the batt to engine ground, chassis to engine/batt ground & the engine to body grounds.
    1988 Chevy C-3500 2wd (no pic)
    350 c.i. 5.7 L Stock Block, 4 Bolt Mains
    L-31 Vortec Heads, Edelbrock Cam & Intake,
    Holley 650, Flowtech Headers, Magnaflow exh.
    Jet Trans 700R4, B&M Ratchet, 4:10 gears,
    3" susp. lift kit "shadetree"
    No rev limiter, No speed limiter lol


  4. #4

    Default

    Thanks stephan, I should've mentioned that its the 6.5 TD and I just had the intake off to replace the fuel lines and wire wheeled the engine to battery ground on the driver side and another ground (small black wire) on the passenger side by the transmission dipstick tube. It all ran ok for a couple months except the AC blower motor problem. I replaced everything and still no blower. As I understand it the High setting does not pass through the resistor. Its not blowing any fuses and there's power all the way to the blower except on "High".. I do not know for sure if the other problems are related because the wipers haven't been used in a while because we have a drought here. The radio, dash lights, gauges and warning lights and everything else have good ground and no problems (so far). I'll look for other grounds and see.

Similar Threads

  1. New part blower motor black silverado 2500
    By Steve in forum Chevy Parts eBay
    Replies: 0
    Last Post: 06-18-2011, 03:22 AM
  2. New part blower motor black silverado 2500
    By Steve in forum Chevy Parts eBay
    Replies: 0
    Last Post: 04-25-2011, 12:00 PM
  3. New part blower motor black silverado 2500
    By Steve in forum Chevy Parts eBay
    Replies: 0
    Last Post: 03-25-2011, 08:10 AM
  4. New part blower motor black silverado 2500
    By Steve in forum Chevy Parts eBay
    Replies: 0
    Last Post: 03-07-2011, 06:50 AM
  5. New part blower motor black silverado 2500
    By Steve in forum Chevy Parts eBay
    Replies: 0
    Last Post: 02-05-2011, 05:51 AM

Tags for this Thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •