GM Truck Club
THE PREMIER CHEVY TRUCK & SUV FORUM
Founded in 2004 ~ We're the #1 Chevy Truck & SUV Forum.
Silverado & Sierra | Tahoe & Yukon | Suburban & Yukon XL | SUV & CROSSOVER
Results 1 to 3 of 3
  1. #1

    Default my 1992 gmc sierra has issues

    dont know if i am in right place but i need HELP!! replaced fuel pump/ filter on my 92 sierra and now wont crank. fuse is good , truck starts when pump is straight-wired and runs great til wires off. only one of three wires in pump plug getting fire what to do?? where to begin??

  2. #2

    Default

    If you mean 12 volts read on a voltmeter is "fire", try a test light that pulls some amperage to ensure you aren't getting a fuel gauge sensor voltage. Make sure the unit is properly grounded. One of the wires is probably ground. I don't own a '92 so I'm shooting in the dark, but if there's a relay, check/jumper it or swap it with a new one. Check the fuse, replace it if there's any doubt. Voltage doesn't run anything, it's current.

  3. #3

    Default

    If it runs with outside-source power to the pump, then you need to check the fuel pump relay AND the oil pressure switch (under the distributor). The connector at the pump should only have power to the fuel pump when the computer activates the relay or the oil pressure switch is closed. The other wire with "fire" is probably the fuel gage wire. HTH
    Good Luck and God Bless

Similar Threads

  1. Audio Help with audio setup for my 1992 gmc sierra single cab
    By ANTEC900 in forum Audio, Video & Gadget Tech
    Replies: 8
    Last: 11-24-2011, 11:42 AM
  2. 1992 4.3 sierra wont start unless gas petal to the floor
    By WorkTruck 4.3 in forum GM Powertrain
    Replies: 7
    Last: 08-05-2011, 10:49 PM
  3. 1992 GMC Sierra Project
    By baldana in forum Photo & Video Gallery
    Replies: 3
    Last: 05-24-2011, 07:35 AM
  4. 1992 GMC Sierra Project
    By baldana in forum Member Introductions
    Replies: 0
    Last: 05-21-2011, 02:39 PM
  5. just bought a 1992 suburban and issues....need advice ASAP!
    By 92burb in forum General Chevy & GM Tech Questions
    Replies: 6
    Last: 12-02-2010, 07:10 AM

Tags for this Thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •