GM Truck Club
THE PREMIER CHEVY TRUCK & SUV FORUM
Founded in 2004 ~ We're the #1 Chevy Truck & SUV Forum.
Silverado & Sierra | Tahoe & Yukon | Suburban & Yukon XL | SUV & CROSSOVER
Results 1 to 2 of 2
  1. #1

    Default I just did the steering rattle recommended temporary fix

    I wonder why I waited too long to do this. The steering is now quiet and no more rattle. I removed the lower bolt inside the engine compartment and slid the shaft in and out a few times to distribute the grease back into the male and female splines. What happens was, over time the grease dries up from getting pushed into the rear cavity of the spline assembly and metal to metal contact happens due to the looser clearance from absence of grease. Just removing the bottom bolt allows you to move the male splines all the way back to the cavity and this pushes the grease residing there back into the splines. I know this is a temporay fix, but next time it dries up, I will just pull the steering shaft out, drill and tap a hole for a small grease fitting so I can re-grease the splines without pulling it out. I will also use a stickier grease. I know some of you will say just get the updated shaft and be done with it. I am cheap!
    2011 Chevy Silverado LT 4WD 30k miles
    2001 Suburban 2WD, 5.3, V8 185k miles
    1993 964
    1996 318TI

  2. #2

    Default

    I posted on the wrong forum. This should go to the Suburban forum. Moderator, please move to Suburban forums. Thanks.

Similar Threads

  1. Steering Clunk/Rattle
    By Sitkaspruce in forum General Chevy & GM Tech Questions
    Replies: 14
    Last: 11-19-2009, 02:49 PM
  2. Power Steering Whine and Heat Shield Rattle Question...
    By Burnall4 in forum General Chevy & GM Tech Questions
    Replies: 0
    Last: 06-29-2009, 10:37 AM
  3. 06 2500HD 6.0 4x4 Crew steering rattle
    By magstar67 in forum Chevy Silverado Forum (GMC Sierra)
    Replies: 2
    Last: 04-25-2009, 09:54 AM
  4. Steering Column Clunk/rattle
    By gregg in forum General Chevy & GM Tech Questions
    Replies: 16
    Last: 01-22-2009, 11:49 PM
  5. Temporary disable DRLs???
    By peacekeeper in forum Chevy Suburban Forum (GMC Yukon XL)
    Replies: 4
    Last: 03-02-2007, 01:25 PM

Tags for this Thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •